OPL800TX Datasheet OPL800TXV, OPL800TX | P1-P2

High Reliability Photologic®

Hermetic Sensors

OPL800TX, OPL800TXV

Issue A 11/2016 Page 1

OPTEK Technology, Inc.

1645 Wallace Drive, Carrollton, TX 75006|Ph: +1 972 323 2200

www.optekinc.com | www.ttelectronics.com

General Note

TT Electronics reserves the right to make changes in product speciﬁcation without

notice or liability. All information is subject to TT Electronics’ own data and is

considered accurate at time of going to print.

Description:

TheOPL800TX/TXVisahighreliabilityoptoelectronicmicrocircuitthatincorporatesaphotodiode,linearampliﬁerand

Schmitriggeronasinglesiliconchip.ThedevicefeaturesTTL/STTLcompablelogicleveloutputwhichcandriveupto8

TTLloadswithoutaddionalinterfacecircuitry.ThePhotologic

chipismountedonastandardTO‐18headerwithgold

platedleadswhichishermecallysealedinalensedgoldplatedmetalcan.Thesedevicesaremechanicallyandspectrally

matchedtotheOP235TX/TXVandOP236TX/TXVinfraredemingdiodes.AllpartsareprocessedtoOptek’s100percent

screening

programpaernedaerMethod5004ofMIL‐STD‐883andthequalityconformancetesngofMethod5005.

TypicalcharacterisccurvesareshownonthecommercialOPL800datasheet.



Applications:

 Non-contact reﬂective object sensor

 Assembly line automation

 Machine automation

 Machine Safety

 End of travel sensor

 Door sensor

 Military and harsh environments

Features:

 100% screened and quality conformance tested to Optek’s High

Reliability program

 Direct TTL/STTL interface

 Hermetic, lensed TO-18 package

 Mechanically and spectrally matched to OP235/OP236TX/TXV LEDs

(2)

(1)

(3)

Absolute Maximum Rangs (T

A

=25°Cunlessotherwisenoted)

SupplyVoltage,V

(nottoexceed3sec) +10.0V

StorageTemperatureRange ‐55°Cto+150°C

OperangTemperatureRange ‐55°Cto+125°C

LeadSolderingTemperature[1/16inch(1.6mm)fromcasefor5sec.withsolderingiron] 240°C

(1)



PowerDissipaon 250mW

(2)



DuraonofOutputShorttoV

orGround 1.00sec

Irradiance 3mW/cm



Notes:

1. RMAﬂuxisrecommended.Duraoncanbeextendedto10secondsmaximumwhenwavesoldering.

2. Deratelinearly2.5mW/°Cabove25°C.

3. Lightmeasurementsaremadewithλ=935nm.

General Note

TT Electronics reserves the right to make changes in product speciﬁcation without

notice or liability. All information is subject to TT Electronics’ own data and is

considered accurate at time of going to print.

High Reliability Photologic®

Hermetic Sensors

OPL800TX, OPL800TXV

Issue A 11/2016 Page 2

OPTEK Technology, Inc.

1645 Wallace Drive, Carrollton, TX 75006|Ph: +1 972 323 2200

www.optekinc.com | www.ttelectronics.com

Group A Inspecon‐Electrical Tests

(Performedoneachinspeconlotaeralldeviceshavebeensubjectedtothe100%processingrequirements.)

SYMBOL EXAMINATION OR TEST METHOD N/C

LIMIT

UNITS

MIN MAX

Subgroup 1

(3)



CCH



SupplyCurrent,High

3005 V

=5.5V,E

=1.0mw/cm



116/0



15.0 mA

CCL



SupplyCurrent,Low 3005 V

=5.5V,E

=0.0mw/cm

15.0 mA



LowLevelOutputVoltage 3007

=4.5V,I

=12.8mA,

=0.0mw/cm



 0.40 V



HighLevelOutputVoltage 3006

=4.5V,I

=‐800μA,E

=

1.0mw/cm



2.4 V



ShortCircuitOutputCurrent 3011

=4.5V,E

=1.0mw/cm

Output=

Ground

‐20‐100 mA

Subgroup 2

(3)

TA = +125°C

CCH



SupplyCurrent,High 3005 V

=5.5V,E

=1.0mw/cm



116/0

 15.0 mA

CCL



SupplyCurrent,Low 3005 V

=5.5V,E

=0.0mw/cm

15.0 mA



LowLevelOutputVoltage 3007 V

=4.5V,I

=12.8mA,  0.40 V



HighLevelOutputVoltage 3006 V

=4.5V,I

=‐800μA,E

= 2.4 V

Subgroup 3

(3)

TA = ‐55°C

CCH



SupplyCurrent,High 3005 V

=5.5V,E

=1.0mw/cm



116/0



 15.0 mA

CCL



SupplyCurrent,Low 3005 V

=5.5V,E

=0.0mw/cm

15.0 mA



LowLevelOutputVoltage 3007

=4.5V,I

=12.8mA,

=0.0mw/cm



 0.40 V



HighLevelOutputVoltage 3006

=4.5V,I

=‐800μA,E

=

1.0mw/cm



2.4 V

Subgroup 3

(3)



,t



RiseandFallTime 3004 V

=5.0V,R

=8TTLloads

116/0



 100 ns

PHL



PropagaonDelay,Low‐High 3003 V

=5.0V,R

=8TTLloads10.0μs

PLH



PropagaonDelay,High‐Low 3003 V

=5.0V,R

=8TTLloads10.0μs

CONDITIONS

P1-P2

OPL800TX

Mfr. #:

Buy OPL800TX

Manufacturer:

Optek / TT Electronics

Description:

Photo IC Sensors PHOTOLOGIC HERMETIC SENSOR

Lifecycle:

New from this manufacturer.

Delivery:

DHL FedEx Ups TNT EMS

Payment:

T/T Paypal Visa MoneyGram Western Union

OPL800TX

OPL800TX

Products related to this Datasheet